VWDiesel.net The IDI, TDI, and mTDI source.
Engine Specific Info and Questions => TDI - VE Pump TDI Engines => Topic started by: Tmarkle on April 23, 2018, 09:43:12 pm
-
Just picked up a 98 Jetta TDI for dirt cheap. Runs pretty solid and has good power, I drove it 150 miles home from Wyoming to Montana and it performed great. However it has a smoking issue. When idling, it constantly smokes a bit of white. It is unburied diesel, burns your eyes and such. When revving, it is a very light grey haze, and after driving there will be no smoke till it sits and idles for a minute. The smoke is much more noticeable cold but is still there when warm. The intake is pretty dang plugged and I found a tiny diesel leak on the bottom of the pump head. There was a small bubble sitting in the feed line to the injection pump, so I’m thinking that maybe there’s some air in the system? I’m my Toyota diesel swap thread I know I put AHU, my mistake, I didn’t actually look at the code till today.
Sent from my iPhone using Tapatalk
-
It might be air in the lines or timing. Best get out the dial gauge and see if it is advanced a bit too far or not far enough.
-
It might be air in the lines or timing. Best get out the dial gauge and see if it is advanced a bit too far or not far enough.
Can I adjust the timing on the tdi by tilting the pump? I thought I’d need to use a computer to do that.
Sent from my iPhone using Tapatalk
-
I think I misunderstood some of my readings. Can I adjust the TDI timing using my dial gauge for IDIs?
-
Deferring to someone with knowledge of TDI timing. I don't know if the IDI method is the same. Likely not as the age and engine is way better than something from the 1980's inventors.
-
You need vag-com for timing the TDIs.
Fix the fuel leak, double-check that the cam timing is spot on, double-check the pump timing.
-
I scanned the following codes and have gathered some info on what they are.
P0380 Glow plug fault
P1619 Glow plug relay fault
P1144 MAF ??
P1258 Coolant temp short ??
P1161 Intake air temp ??
I’m thinking these may be pointing to to my issue. The fuel “leak” I found was because I tried to bleed air out of the injectors and it ran down lol
Sent from my iPhone using Tapatalk
-
Ran a clear lines from the filter to the pump and discovered tons of bubbles coming into the pump. I ran a clear line from the filter to a bottle of fuel and a clear line from the return back to the bottle. I eliminated bubbles coming in but the return line is full of tiny bubbles. Stopping the air coming in greatly reduced the white smoke, yet there is still a small amount. I haven't looked any closer into the codes. I really need to bite the bullet and buy a laptop and VCDS.
-
So, what does the smoke smell like? Sweet like coolant, like diesel, or like oil?
Or is this problem already sorted and you didnt reply because of people like me who werent here and didnt reply because we didnt see the post?
Just wondering...
PH